Whole-body vibration, lower back pain is a concern to some farmers
During harvest, it is common for farmers to work from daybreak until sundown, 10 to 14 hours a day. Putting in long hours, while sitting on the equipment can be mentally exhausting and take a physical toll on the body. A new study, conducted by researchers at the University of Iowa College of Public Health, examined whole-body vibration exposures during the operation of several types of agricultural machinery. A paper describing results of the study appear in the October edition of Annals of Work Exposure and Health. Whole-body vibration is defined as mechanical vibrations that are transmitted to the human body through a contact surface, such as a seat. “Exposure to whole-body vibration is a key occupational risk factor back pain, which is common among agricultural workers,” said the study’s lead investigator, Dr. Nathan Fethke. “Most working people, at some point in life, will experience an episode of back pain that limits work activity for a few days. Spending many hours operating machinery can increase the frequency of back pain episodes and, if the pain is severe or becomes chronic, medical costs can be quite high.” For example, a previous study found that costs associated with lower back pain in the United States exceeded $100 billion per year, two thirds of which are a result of lost wages and productivity—and that study was over a decade ago. Very little is known regarding how much is related specifically to the agricultural industry. Nevertheless, reducing exposures to whole-body vibration can help improve health and may reduce long term health care costs.
Fethke’s team measured whole-body vibration by attaching sensors to the seats of more than 100 machines, including tractors, combines, forklifts, skid loaders, and all-terrain vehicles (ATVs), as more than 50 Midwestern farmers went about their daily routines. An additional sensor attached to the floor of each machine allowed Fethke’s team to examine how effectively the seats reduced the vibration levels.
The average vibration levels were compared to the European Union’s (EU) whole-body vibration exposure limits, which are similar to recommendations made by the American Conference of Governmental Industrial Hygienists (note: the U.S. Occupational Safety and Health Administration does not enforce a whole-body vibration standard). The whole-body vibration levels of nearly 30% of the machines were high enough to reach EU’s ‘action level’ within only two hours of operation (the action level is defined as the level above which the risk of health effects increases).
Combines exhibited the lowest levels of whole-body vibration exposures, which, according to Fethke, was “likely due to a combination of the mass of combines compared to other machine types and the common presence of relatively sophisticated seat suspension systems.” The combine seats, in fact, reduced by half the amount of vibration measured at the floor. Tractors and heavy utility vehicles did not fare as well, with average vibration levels about double what was measured on combines. Fethke adds, “Special seat-based suspension systems, particularly on tractors, did not dramatically reduce whole body vibration like we thought they would– it is possible that these suspension systems were not properly adjusted to the weight of the operator, or had degraded over time from mechanical wear and tear.”
During the low season, farmers should check seat suspension systems to make sure they are greased and working properly. Whatever the season, make sure the seat suspension is properly adjusted for the operator’s body weight. This is especially important if several workers or family members will be operating the equipment. If the seat tends to frequently “bottom out,” even after proper adjustment for body weight and routine maintenance, it is time to consider a replacement.
Finally, the potential effects of whole-body vibration on back pain and discomfort also depend on the operator’s posture in the seat. “As any experienced agricultural equipment operator knows, it is often necessary to lean far forward or look to the side or behind the equipment for visibility purposes. However, these twisting postures change how the body responds to vibration and can increase the risk of back problems down the road,” said Fethke.
The study is one of few to look at whole body vibration during the operation of agricultural machinery. To read the entire article, Whole-Body Vibration and Trunk Posture during Operation of Agricultural Machinery, go to https://doi.org/10.1093/annweh/wxy076. For posters and handouts in English and Spanish with recommendations on reducing whole body vibration, view http://bit.ly/WBVrecommendations.
–Great Plains Center for Agricultural Health
Start a dialogue, stay on topic and be civil.
If you don't follow the rules, your comment may be deleted.
User Legend: Moderator Trusted User
While Biden has overturned a number of previous administrations’ policies, his plans for managing the 1971 Free-Roaming Wild Horse and Burro Act (The Act) are still up in the air. But environmentalist groups are leading…